Glass Marker
 |
US $15.00
How to Cut, Score and Break Glass
Glass can be cut into strips, geometric shapes, circles, ovals, curves and with a glass saw, almost any shape.
Some Things to Keep in Mind
• Warm glass (glass at room temperature) cuts easier than cold glass
• Work surface needs to be flat
• Score on the smooth side of glass rather than on the textured side
• Hold glass cutter in a vertical position as you would a pen or pencil
• Don’t use excessive pressure. Too deep of a score can result in a bad break
• For protection, it’s a good idea to wear glasses or another type of eye protection
Straight Cuts
When making a straight score, start scoring the glass from the point farthest from your body and pull the glass cutter towards you. Once a score line is made, use running pliers (if strip is at least 1” wide) by placing the running pliers centered on the score line and gently squeeze the handles. You will hear a slight cracking noise and see the glass separate along the score line. Or, hold the stained glass sheet over an edge of a table with the score line slightly overhanging the edge. Use breaking or grozier pliers and apply gentle pressure in a downward motion along the score line. This can also be done with your hands using the same downward motion. Practice will make for perfection, soon.
Curve Cuts
To make a curved cut, use the glass cutter to cut off sections one at a time. This allows you to work into the curve. Glass likes straight lines or lines with gentle bends. If the shape has irregularities or small projections, these are easily removed with a nipper or glass grinder. In other words, don’t rush the cut especially if it is an inside curve. Just chip away at it a little bit at a time.
Cutting Circles
Score the glass in the shape and size of the desired circle. Use a permanent marker to place a dot where you start scoring to avoid going over the starting point. Next, place the scored line side of the glass down on a piece of corrugated cardboard. Use light pressure and press along the score line until you see it run the circle. Then, turn the glass over to the side you first scored on and score several tangent cuts radiating out from the circle. Finally, break each tangent score line with breaking pliers. The circle should cut clean without any jagged edges.
How To Avoid Common Problems
• Cutter wheel wears out quickly – Lift your cutter up instead of sliding it off the edge of the glass or cut on a surface covered with vinyl or carpet
• Bad breaks after scoring – Too much pressure was applied on the glass cutter
• Score line looks like dotted line – Cutter wheel is dull and needs to be replaced
Be sure to turn your pattern template over when you are tracing your pattern onto the backside of the glass where it smoother. Failure to do this will end up in wasted glass and lots of wasted time, not to mention frustration.
About the Author
I started out as a stained glass admirer. After a class in stained glass, I became addicted. At first I made stained glass to decorate my home, which lead to friends asking me to make stained glass for them. Now I am a full time professional making stained glass as well as instructing others on how to make stained glass. My studio is located outside of Chicago, Illinois. For more information on making or buying stained glass, to find a free pattern or to sign up for my newsletter, go to http://www.creativity-in-glass.com
|
|
Pebeo Frosted Paint Marker Set $54.95 Add Detail To Your Glass. Use paint markers with Pebeo paints and outliners. The medium-size round tip makes drawing, writing and outlining a breeze. After baking in a domestic oven for 40 minutes, the depth of the color is enhanced. Lead-free, food safe and dishwasher safe. Set includes 9 markers. Paint marker color image below courtesy of Pebeo. Image of marker in use from Creative Glass Painting 6976. Paint markers are a fun and easy way to create personalize gifts, as shown below. |
|
|
Pebeo Glossy Paint Marker Set $54.95 Add Detail To Your Glass. Use paint to transform plain glass into art. Give functional household items like vases, glasses and plates, plus bevels, mirrors and stained glass a colorful paint makeover. Pebeo and 39;s Vitrea 160 transparent water based glass paints combine professional quality with ease of use. After baking in a domestic oven for 40 minutes, the depth of the color is enhanced. No kiln is needed. Paints are lead-free and dishwater safe. Use paint markers with Pebeo paints and outliners. The medium-size round tip makes drawing, writing and outlining a breeze. Set includes 9 markers. Image of marker in use from Creative Glass Painting 6976. Paint markers are a fun and easy way to create personalize gifts, as shown below. |
|
|
Gold Marker - Medium Point $5.95 Write on glass for tracing patter pieces. Pen writes in a metallic ink that holds up better in water while grinding. The ink is also easily seen on dark glass. For even better results, preserve your lines with Mark Stay II (item 50481). |
|
|
Gold Marker - Fine Point $5.95 Write on glass for tracing patter pieces. Pen writes in a metallic ink that holds up better in water while grinding. The ink is also easily seen on dark glass. For even better results, preserve your lines with Mark Stay II (item 50481). |
|
|
Silver Marker - Medium Point $4.95 Write on glass for tracing patter pieces. Pen writes in a metallic ink that holds up better in water while grinding. The ink is also easily seen on dark glass. For even better results, preserve your lines with Mark Stay II (item 50481). |
|
|
Black Glossy Paint Marker - 8 Ml $8.95 Add Detail To Your Glass. Use paint to transform plain glass into art. Give functional household items like vases, glasses and plates plus bevels, mirrors and stained glass, a colorful paint makeover. Pebeo and 39;s Vitrea 160 transparent water based glass paints combine professional quality with ease of use. After baking in a domestic oven for 40 minutes, the depth of the color is enhanced. No kiln is needed. Paints are lead-free and dishwater safe. 8 ml. Use paint markers with Pebeo paints and outliners. The medium-size round tip makes drawing, writing and outlining a breeze. Image of marker in use from Creative Glass Painting 6976. Paint markers are a fun and easy way to create personalize gifts, as shown below. |
|
|
Pilot Creative Permanent Marker $2.99 0% 0.96 oz 1 Each 41700 Marker is permanent on most surfaces including paper, glass, plastic, photos. Marker is ideal for decorating, illustration, touch ups and identification. Creative Creative Permanent Marker Gold Gold Plated Medium No Permanent Marker Pilot Pilot Corporation www.pilotpen.us |
|
|
Pilot Extra Fine Marker $4.99 0% 1 Each 41500 Gold Marker delivers sparkling gold that adds a dramatic bold effect. Extra fine point marks permanently on most surfaces including glass, photos, plastic, paper and more. Ideal for crafts. Extra Fine Marker Fine Gold No Permanent Marker Pilot Pilot Corporation Point www.pilotpen.us |
|
|
Pilot Jumbo Permanent Marker $2.99 0.96 oz 1 Each 10 mm 43200 Mark permanently on almost all surfaces, including glass, metal, wood and plastics Super-size industrial sign marker features a fast-drying, waterproof permanent ink supply. Use marker on any surface. Marker delivers a thick stroke with 10mm chisel felt tip. Refillable. Blue Chisel Jumbo Jumbo Permanent Marker Permanent Marker Pilot Pilot Corporation Quick-drying Ink Yes www.pilotpen.us |
|
|
Blue Window Marker $2.99 Blue Window Marker is for use on clean,dry surface only. Do not use on car body,paint,wood,clothing or any other non-glass surface. To use: Shake Window Marker well and then pull off cap. Press marker sponge tip against window and squeeze gently to start flow. Allow Window Marker to dry for about 10 minutes. To remove: Sponge off with soap and warm water. Warning: Choking Hazard - small parts. Not for children under 3 years. |
|
|
Red Window Marker $2.99 Red Window Marker is for use on clean,dry surface only. Do not use on car body,paint,wood,clothing or any other non-glass surface. To use: Shake Window Marker well and then pull off cap. Press marker sponge tip against window and squeeze gently to start flow. Allow Window Marker to dry for about 10 minutes. To remove: Sponge off with soap and warm water. Warning: Choking Hazard - small parts. Not for children under 3 years. |
|
|
Orange Window Marker $2.99 Orange Window Marker is for use on clean,dry surface only. Do not use on car body,paint,wood,clothing or any other non-glass surface. To use: Shake Window Marker well and then pull off cap. Press marker sponge tip against window and squeeze gently to start flow. Allow Window Marker to dry for about 10 minutes. To remove: Sponge off with soap and warm water. Warning: Choking Hazard - small parts. Not for children under 3 years. |
|
|
Green Window Marker $2.99 Green Window marker should be used on a clean,dry surface only. Do not use on car body,paint,wood,clothing or any other non-glass surface. To use: Shake Window Marker well and then pull off cap. Press marker sponge tip against window and squeeze gently to start flow. Allow Window Marker to dry for about 10 minutes. To remove: Sponge off with soap and warm water. Warning: Choking Hazard - small parts. Not for children under 3 years. |
|
|
Purple Window Marker $2.99 This Purple Window Marker is for use on clean,dry surface only. Do not use on car body,paint,wood,clothing or any other non-glass surface. To use: Shake Window Marker well and then pull off cap. Press marker sponge tip against window and squeeze gently to start flow. Allow Window Marker to dry for about 10 minutes. To remove: Sponge off with soap and warm water. Warning: Choking Hazard - small parts. Not for children under 3 years. |
|
|
Black Window Marker $2.99 Use Black Window Marker on clean,dry surface only. Do not use on car body,paint,wood,clothing or any other non-glass surface. To use: Shake Window Marker well and then pull off cap. Press marker sponge tip against window and squeeze gently to start flow. Allow Window Marker to dry for about 10 minutes. To remove: Sponge off with soap and warm water. Warning: Choking Hazard - small parts. Not for children under 3 years. |
|
|
Dixon RediSharp Permanent Marker $6.99 0% 1 / Each 97201 PMA (nontoxic) Tough Permanent Marker offers a quality marking system that is ideal for safely marking on paper, coated paper, plastic, glass, metal, aluminum foil, leather and wood. Marker is alcohol based, yet virtually odor-free compared to other permanent markers. Includes a vented safety cap. Certified AP nontoxic. Alcohol Based Dixon Dixon Ticonderoga Company Fine No Permanent Marker Red RediSharp Permanent Marker Redisharp Rubber Grip www.dixonticonderoga.com |
|
|
Expo Fine Point Marker $10.99 0% 12 / Set 86603 AP Dry erase marker contains specially formulated low odor, dry erase ink. Perfect for classrooms, small offices and homes. Can be used on most whiteboards, glass and nonporous surfaces. Dry erase marker with fine point delivers consistent color quality for bold colors and great erasability. Certified AP nontoxic and conforms to ASTM D-4236. Assorted Chisel Dry Erase Marker Expo Fine Point Marker Low-odor Ink No Non-toxic Sanford, L.P. www.sanford.com |
|
|
Sanford Fine Industrial Marker $10.99 0% 12 / Dozen 13601 Industrial Marker with extra fine point is ideal for industrial, laboratory and specialty use. Permanent ink remains permanent on metal, foil, glass, photographic film, plastic and most hard to mark surfaces, even in extreme heat and steam. Marker is water resistant and smearproof. Black Fine Fine Industrial Marker No Permanent Marker Sanford Sanford, L.P. Smear-proof Ink Water Resistant www.sanford.com |
|
|
BIC Mark-it Permanent Marker $1.99 0% 1 Each Mark-it Retractable Permanent Marker offers long-lasting, acid-free ink with a durable fine point tip. Seal Guard defends against dry out. Use to mark on glass, metal, plastics, photos, foils, coated paper, oily surfaces, damp surfaces and more. Permanent marker retracts with an easy click. Acid-free Ink BIC Black Comfort Grip Fine Mark-it Mark-it Permanent Marker No PMRP11BK Permanent Marker Point Washable Yes www.bicworld.com |
|
|
Dixon Phano China Marker $6.99 0% 00074 12 / Dozen The china marker makes beautiful bold strokes on almost any porous or non-porous surface including glass, plastic, film, paper, metal, and rubber. Marks wipe away clean and are paper wrapped with a tear string for easy sharpening. Available in a selection of bright, brilliant colors. China Marker Pencil Dixon Dixon Ticonderoga Company Green No Non-toxic PMA Phano Phano Non-Toxic China Marker www.dixonticonderoga.com |
|
|
Expo Dry Erase Marker $11.99 0% 12 / Dozen 86003 AP ASTM D-4236 Dry-erase marker contains specially formulated low-odor, dry-erase ink. Perfect for classrooms, small offices and homes. Can be used on most whiteboards, glass and nonporous surfaces. Dry-erase marker with fine point delivers consistent color quality for bold colors and great erasability. Certified AP nontoxic and conforms to ASTM D-4236. Blue Dry Erase Marker Expo Fine Low-odor Ink No Sanford, L.P. www.sanford.com |
|
|
Yellow Window Marker $1.96 This Window marker is perfect for house or car windows,whether you're encouraging your team,congratulating your graduate or announcing the bride and groom. Use on clean,dry surface only. Do not use on car body,paint,wood,clothing or any other non-glass surface. To use: Shake Window Marker well and then pull off cap. Press marker sponge tip against window and squeeze gently to start flow. Allow Window Marker to dry for about 10 minutes. To remove: Sponge off with soap and warm water. Warning: Choking Hazard - small parts. Not for children under 3 years. |
|
|
White Marker white $4.02 This quick drying, white opaque marker writes on metal, glass, plastic, rubber, and most non-porous surfaces, permanently. It writes fine lines and features a slim barrel with a snap-on cap.Each package comes with two spare nibs. |
